Wang Chang, Ai Di, Yu Zhentao, et al. Finite Element Simulation of the Drawing Process for Pure Magnesium Thin Wire[J]. Special Casting & Nonferrous Alloys, 2018,38(8):850-852.
Wang Chang, Ai Di, Yu Zhentao, et al. Finite Element Simulation of the Drawing Process for Pure Magnesium Thin Wire[J]. Special Casting & Nonferrous Alloys, 2018,38(8):850-852. DOI: 10.15980/j.tzzz.2018.08.010.
纯镁细丝拉拔的有限元模拟
摘要
以热压缩本构方程为基础
控制不同的摩擦因数、拉拔速度以及道次变形量
对纯镁细丝的拉拔工艺进行了有限元模拟。结果表明
随着摩擦因数的增加
拉拔力、应变不均匀度、最大主应力均增加;随着拉拔速度的增加
拉拔力变化不大
应变不均匀度、最大主应力逐渐增加
当拉拔速度高于60mm/s时
最大主应力急剧增加;随着道次变形量的增加
断裂倾向值增加
当道次变形量大于15%时
断裂倾向值显著增加。纯镁细丝较优的拉拔工艺参数:摩擦因数为0.08
拉拔速度低于60mm/s
道次变形量为10%
1
5%。
Abstract
The drawing process of pure magnesium thin wire was numerically simulated by controlling the different friction coefficients
drawing speeds and the amount of pass deformations based on the constitutive equations established by the thermal compression.The results reveal that drawing force and strain non-uniformity as well as maximum main stress are increased with the increase of the friction coefficient.With the increase of drawing speed
the change of drawing force can be ignored
while the strain non-uniformity and the maximum main stress are increased gradually.The maximum main stress is increased dramatically when the drawing speed is more than 60 mm/s.With the increase of pass deformation
the fracture tendency value is increased and it is increased sharply at pass deformation exceeding 15%.Therefore
the optimized drawing parameters of pure magnesium thin wire are presented as follows:the friction coefficient of 0.08
the drawing speed less than 60 mm/s and the pass deformation in range of10%
1
5%.
关键词
纯镁细丝有限元模拟摩擦因数拉拔速度道次变形量
Keywords
Pure Magnesium WireFinite Element SimulationFriction CoefficientDrawing SpeedPass Deformation