微量Sc对Mg-7Gd-3Y合金组织及力学性能的影响

刘彪; 刘子利; 刘细良

轻有色合金 | 浏览量 : 0 下载量: 79 CSCD: 1

导出
分享
收藏
专辑

微量Sc对Mg-7Gd-3Y合金组织及力学性能的影响
Effects of Minor Sc Addition on Microstructure and Mechanical Properties of Mg-7Gd-3Y Alloys
2009年29卷第7期页码：653-655
纸质出版日期： 2009 ，
DOI：

扫描看全文

[1]刘彪,刘子利,刘细良.微量Sc对Mg-7Gd-3Y合金组织及力学性能的影响[J].特种铸造及有色合金,2009,29(07):653-655+586.

Liu Biao, Liu Zili, Li Xiliang. Effects of Minor Sc Addition on Microstructure and Mechanical Properties of Mg-7Gd-3Y Alloys[J]. Special Casting & Nonferrous Alloys, 2009,29(7):653-655.
[1]刘彪,刘子利,刘细良.微量Sc对Mg-7Gd-3Y合金组织及力学性能的影响[J].特种铸造及有色合金,2009,29(07):653-655+586. DOI：

Liu Biao, Liu Zili, Li Xiliang. Effects of Minor Sc Addition on Microstructure and Mechanical Properties of Mg-7Gd-3Y Alloys[J]. Special Casting & Nonferrous Alloys, 2009,29(7):653-655. DOI：

摘要

利用光学显微镜、扫描电镜和XRD

分析研究了微量Sc对Mg-7Gd-3Y铸态合金组织及其室温和200℃力学性能的影响。结果表明

在合金中加入0.5%的Sc

促进了Mg24（Y

Gd）5和Mg5（Gd

Y）相的析出

降低Gd在Mg24（Y

Gd）5相中的相对含量

合金的室温和200℃时的抗拉强度分别提高了25MPa和18MPa;屈服强度分别提高了28MPa和22MPa;伸长率分别提高了18.3%和37.8%。

Abstract

Effects of minor Sc addition on microstructure and mechanical properties of the as-cast Mg-7Gd-3Y alloys at room temperature and at 200℃ were investigated by optical microscope （OM）

scanning electron microscope and XRD. The results show that with 0.5%Sc addition

the alloy at room temperature and at 200℃ is increased by 25MPa and 18MPa in tensile strength and by 28 MPa and 22MPa in yield strength as well as by 18.3% and 30.2% in elongation

respectively

as a result of promoting the precipitation of Mg24（Y

Gd）5 and Mg5（Gd

Y） phase and decreasing the relative content of Gd in Mg24（Y

Gd）5 phase.