English Version
实用研究 | 浏览量 : 31 下载量: 102 CSCD: 5
  • 导出

  • 分享

  • 收藏

  • 专辑

    • 高锰ZA35合金中富锰相的电化学行为

    • Electrochemical Behavior of Mn-enriched Phase in High Mn ZA35 Alloy

    • 刘敬福

      12

      崔佳

      1

      李荣德

      2

      宋建

      2

      陈鹏飞

      2
    • 2011年31卷第6期 页码:510-513   

      纸质出版日期: 2011

    扫 描 看 全 文

  • 引用

  • [1]刘敬福,崔佳,李荣德,宋建,陈鹏飞.高锰ZA35合金中富锰相的电化学行为[J].特种铸造及有色合金,2011,31(06):510-513. DOI:
    Liu Jingfu1, Cui Jia1, Li Rongde2, et al. Electrochemical Behavior of Mn-enriched Phase in High Mn ZA35 Alloy[J]. Special Casting & Nonferrous Alloys, 2011,31(6):510-513. DOI:
  •  
  •  
    论文导航

    摘要

    为了探索析出的富锰相对高锰ZA35合金电化学腐蚀性能的影响规律,根据高锰ZA35合金中富锰相的元素组成,熔炼出析出相MnAl6。采用动电位极化方法测试了富锰相MnAl6和ZA35-1.2Mn合金在NaCl水溶液中的开路电位和极化曲线,利用X-射线衍射仪(XRD)检测了合金的相组成。结果表明,随着NaCl溶液温度升高,合金的开路电位下降,并且富锰相MnAl6较ZA35-1.2Mn合金的开路电位低,富锰相MnAl6较ZA35-1.2Mn合金腐蚀电流密度大。ZA35-1.2Mn合金在NaCl含量为3.5%的溶液中,析出的富锰相MnAl6将作为阳极区优先溶解。

    Abstract

    Precipitate phase MnAl6 was fabricated based on element distribution of Mn-enriched in high Mn ZA35 alloy to understand effects of precipitated phase on electrochemical behavior of high Mn ZA35 alloy. Open circuit potential against time and polarization curves of Mn-enriched phase MnAl6 and ZA35-1.2Mn in NaCl aqueous solution were measured by potential dynamic polarization, and phase constituent of the alloy was examined by XRD (X-ray diffraction). The results show that with increasing in temperature of NaCl solution, the open-circuit potential (OCP)of the alloy is shifted gradually into the negative direction, and the OCP of the Mn-enriched phase MnAl6 is lower than that of ZA35-1.2Mn alloy, while corrosion current density is higher than that of the ZA35-1.2 Mn alloy. The precipitate MnAl6 phase in ZA35-1.2Mn alloy is dissolved preferentially as anode zone in 3.5% NaCl aqueous solution.

    关键词

    富锰相; ZA35合金-1.2Mn; 动电位极化; 开路电位; 极化曲线

    Keywords

    Mn-enriched Phase; ZA35-1.2Mn Alloy; Potentiodynamic Polarization; Open-circuit Potential; Polarization Curves

    文章被引用时,请邮件提醒。
    提交

    相关作者

    赵鹏   上海交通大学  
    王渠东   上海交通大学  
    吴从波   上海交通大学  
    贾素秋 长春工业大学材料科学与工程学院
    李均明 西安工业大学材料与化工学院;西安理工大学材料科学与工程学院;西安工业大学材料与化工学院西安理工大学材料科学与工程学院
    王艳红 西安工业大学材料与化工学院;西安理工大学材料科学与工程学院;西安工业大学材料与化工学院西安理工大学材料科学与工程学院
    杨忠 西安工业大学材料与化工学院;西安理工大学材料科学与工程学院;西安工业大学材料与化工学院西安理工大学材料科学与工程学院
    李高宏 西安工业大学材料与化工学院;西安理工大学材料科学与工程学院;西安工业大学材料与化工学院西安理工大学材料科学与工程学院

    相关机构

      上海交通大学  
    长春工业大学材料科学与工程学院
    西安工业大学材料与化工学院
    西安理工大学材料科学与工程学院
    西安工业大学材料与化工学院西安理工大学材料科学与工程学院
    0