Effects of the Solute Interaction on Dendritic Growth in Al-Cu-Mg Alloy

Zhang Xianfei; Zhao Jiuzhou; Zhao Zhongxing

doi:10.15980/j.tzzz.2017.04.001

Views : 0 下载量: 95 CSCD: 0

Export
Share
Collection
Album

Effects of the Solute Interaction on Dendritic Growth in Al-Cu-Mg Alloy
Vol. 37, Issue 4, Pages: 349-353(2017)
Published： 2017 ，
DOI： 10.15980/j.tzzz.2017.04.001

扫描看全文

[1]张显飞,赵九洲,赵忠兴.溶质相互作用对Al-3Cu-1Mg合金枝晶组织的影响[J].特种铸造及有色合金,2017,37(04):349-353.

Zhang Xianfei, Zhao Jiuzhou, Zhao Zhongxing. Effects of the Solute Interaction on Dendritic Growth in Al-Cu-Mg Alloy. [J]. Special Casting & Nonferrous Alloys 37(4):349-353(2017)
[1]张显飞,赵九洲,赵忠兴.溶质相互作用对Al-3Cu-1Mg合金枝晶组织的影响[J].特种铸造及有色合金,2017,37(04):349-353. DOI： 10.15980/j.tzzz.2017.04.001.

Zhang Xianfei, Zhao Jiuzhou, Zhao Zhongxing. Effects of the Solute Interaction on Dendritic Growth in Al-Cu-Mg Alloy. [J]. Special Casting & Nonferrous Alloys 37(4):349-353(2017) DOI： 10.15980/j.tzzz.2017.04.001.

摘要

应用三维元胞自动机模型模拟了Al-3Cu-1Mg合金的树枝晶组织

研究了溶质互扩散对枝晶组织的影响。采用两种方式处理溶质扩散系数:（1）溶质扩散系数与溶质成分和温度有关

不考虑溶质互扩散系数;（2）耦合计算溶质扩散矩阵

即考虑溶质互扩散的影响。结果表明

枝晶尖端选择参数比边缘稳定性理论给出的值小。由于Al-Cu-Mg体系中两种合金元素的相互吸引作用

在溶质互扩散时

枝晶尖端生长速度较小

而尖端半径较大。

Abstract

The dendritic growth of an Al-3Cu-1Mg alloy was calculated using a three-dimensional cellular automaton model.Effects of the off-diagonal terms of the solute diffusion coefficient matrix on the dendritic growth during solidification of the alloy were investigated.The solute diffusion coefficients were treated in two ways:（1）by considering the concentration-dependent and temperature-dependent diffusion

and neglecting the effect of solute interactions or the off-diagonal terms of the diffusion matrix

or（2）by calculating the diffusion coefficients by solving the full diffusion matrix.The results indicate that the calculated dendrite tip selection parameter is the smaller than that obtained using the marginal stability criterion.When the off-diagonal terms of the solute diffusion coefficient matrix are considered

the growth velocity of the dendrite tip is decreased

while the dendrite tip radius is increased as a result of the attraction of the solutes in the Al-Cu-Mg system.